- Product details
- Washing instruction
2/42NM 50 RWS WOOL 50 PAPER
CS4176W
应用
1. 14 针横机，1 根进线
2. 克重：218克/平方米
3. 抗起球标准：7200转(相同花型.针型.张力)为4级
4. 染色工艺：绞纱染色
5. 起订量：样纱6kg/色。
6. 参考分色卡：SAGE
APPLICATION
1. Flat Knitting machines 14 gauge 1 ply
2. Weight per square meter:gr218(on collection fabric on jersey stitch)
3. Pilling grade:4:has been tested on the collection swatch(same stitch/gauge/tension)according to Pilling box(ISO 12945-1/GB/T4802.3) at 7200 turns
4. DYEING PROCESS:Yarn dye
5. MINIMUN:The minimum for yarn dye is 6kgs(sample).
6. For further colors please refer to SAGE color card
织造：
1:纱线已打蜡，尽量不回倒，若必须回倒，联系技术部。
2:成衣为避免色差，织造请连续编织，即前片-后片-衣袖保持同一台机器同一只筒子生产。换筒时，首尾各拉2米，打结后归边，防接头两侧异常。
3:织造车间需保持60%-70%的湿度，横机张力比常规化纤纱线降低30%-40%，避免拉伸导致纸包覆层断裂
4:因纱线比较干爽，如织四空四平等挑空组织易产生破洞，建议织厂要先试生产样衣ok后再生产大货，染色会有AB效果，以样纱品质为准
5.收货后先试织，若有质量问题，15天内反馈。质量问题仅承担同等数量纱线，不负责面料织造和交货期费用。
6.织造时，损耗率10%，涵盖粗细不匀、色差、色花等导致的损耗。
KNITTING：
1:The yarn is waxed; do not re-spool unless necessary. If required, contact our technical department in advance.
2:To avoid color variation, use continuous knitting (front/back panels & sleeves) on the same machine with the same cone. When changing cones, pull 2m from both ends, tie a knot and align the ends to prevent joint defects.
3:Maintain workshop humidity at 60–70%. Reduce flat knitting machine tension by 30–40% vs. conventional synthetic yarns to avoid breaking the paper wrapping layer.
4:Due to low moisture content, openwork patterns (e.g., 4×4 equal openwork) may cause holes. Complete a pre-production trial garment and obtain approval before bulk production. A subtle AB effect is inherent to the dyed yarn; final quality is subject to the approved sample yarn
5.Conduct a trial knit first. Feedback any quality issues within 15 days. Our liability for confirmed issues is limited to providing replacement yarn of the same quantity; we are not responsible for fabric knitting or delivery delays.
6.Standard wastage rate is 10%, covering losses from uneven yarn count, color difference, uneven dyeing, etc.
工业洗涤指示：
1：建议小烫后，30℃左右温水洗涤，加入柔软剂，轻柔滚洗 15 分钟
2：滚筒烘干，温度45℃。
3：熨烫温度小于110℃。
4：不可氯漂。
5: 不同洗衣机机型可能导致绒感效果略有差异，请根据自身需求的绒感状态调整洗涤方法。
WASHING INSTRUCTION：
1：Wash in warm water (max. 30°C) with softener, then tumble wash gently for 15 minutes.
2：Tumble dry at 45℃.
3：Iron at a maximum sole-plate temperature of 110℃.
4：Do not use chlorine bleach.
5: Different machine types may result in slight variations in the final effect. Please adjust the washing method according to the desired fabric nap effect.
| COLOR FASTNESS(Average) | LIGHT COLOUR | SMEDIUM COLOUR | DARK COLOURS | Standard | |||
|---|---|---|---|---|---|---|---|
| Change | Stain | Change | Stain | Change | Stain | ||
| Dry cleaning | 4 | 4 | 4 | 3-4 | 4 | 3 | ISO 105 D01/GB/T 5711 |
| Acid perspiration | 4 | 4 | 4 | 3-4 | 4 | 3 | ISO 104 E04/GB/T 3922 |
| Alkaline perspiration | 4 | 4 | 4 | 3-4 | 4 | 3 | ISO 104 E04/GB/T 3922 |
| Washing | 4 | 4 | 4 | 3-4 | 3 | ISO 105 C06/GB/T 12490 | |
| Dry rubbing | 4 | 4 | 3-4 | ISO 105 X12/GB/T 3920 | |||
| Wet rubbing | 4 | 3-4 | 2-3 | ISO 105 X12/GB/T 3920 | |||
| Light (except white color) | 4 | 3-4 | 4 | ISO 105 B02/GB/T 8427 | |||
For above points marked by *,to refer to OEKO-TEX STANDARD 100 requirements
Above data are average values coming from tests carried out in our laboratories
