- Product details
- Washing instruction
1/20NM 62 WOOL 31 SILK 7 CASHMERE
CM0003
应用
1. 14 针横机，1 根进线
2. 克重：152克/平方米
3. 抗起球标准：7200转(相同花型.针型.张力)为2-3级
4. 染色工艺：散毛染色
5. 起订量：色卡色：样纱1kg/色，大货150kg/色
6. 参考分色卡：DORIAN
APPLICATION
1. Flat Knitting machines 14 gauge 1 ply
2. Weight per square meter:gr152(on collection fabric on jersey stitch)
3. Pilling grade:2-3:has been tested on the collection swatch(same stitch/gauge/tension)according to Pilling box(ISO 12945-1/GB/T4802.3) at 7200 turns
4. DYEING PROCESS:Fibre dye only
5. MINIMUN:Color card:1kg/color bulk:150kg/color
6. For further colors please refer to DORIAN color card
织造：
1:纱线已打蜡，非必要勿回倒，如需回倒请联系技术部
2：不同颜色的纱线在弹性与缩率方面可能存在细微差异，需按色调整工艺
3：拉毛纱在纺纱过程中可能出现毛羽不均情况，请连续编织,如织复杂花型,可能会有破洞，请提前试样。
4：蛋白质纤维耐酸不耐碱，洗水时要留意不能用碱性洗涤剂洗水，后整污染不可打枪处理。
5：收货后先试织，若有质量问题，15天内反馈。质量问题仅承担同等数量纱线，不负责面料织造和交货期费用。
6：织造时，损耗率5%，涵盖粗细不匀、色差、色花等导致的损耗。
7：每个筒有4-5个手工打结处，织造请开启小接头探测器并归边；换筒时首尾各拉2米，打结后归边，防接头两侧异常。
KNITTING：
1: The yarn has been waxed, please do not rewind. Please contact our technical department in advance if rewinding is considered necessary.
2: Yarns of different colors may have slight variations in elasticity and shrinkage. Please adjust the process parameters per color.
3: For brushed yarn, uneven hairiness may occur during spinning. Please knit continuously. Complex patterns may cause holes, so pre-knitting a sample is recommended.
4: Protein fibers are acid-resistant but alkali-sensitive. Do not use alkaline detergents during washing. Do not use air gun spot cleaning for stains caused by post-finishing.
5: After receiving the goods, conduct a trial knitting first. Please report any quality issues within 15 days. For quality problems, we will only be responsible for providing replacement yarn of the same quantity, and will not cover costs related to fabric knitting or delivery delays.
6: During the knitting process, the wastage rate is 5%, which includes the uneven count, color difference, uneven dyeing, etc.
7:Each yarn cone has 4-5 hand-knotted joins. Activate the small join detector and align selvedges during knitting. When changing cones, pull 2 meters from both ends, tie a knot, then align selvedges to prevent joint abnormalities.
工业洗涤指示：
1:建议小烫后。30℃-40℃温水浸泡40分钟，建议轻柔滚洗15分钟。
2：湿烫后平铺晾干。
3：熨烫温度小于110℃.
4：不可氯漂。
5:不同洗衣机机型可能导致绒感效果略有差异，请根据自身需求的绒感状态调整洗涤方法。
WASHING INSTRUCTION：
1: We suggest a light iron first, then soak in 30–40°C warm water for 40 minutes, followed by a gentle tumble wash for 15 minutes.
2: Wet iron the fabric, then lay it flat to dry.
3: Iron at temperature below 110℃.
4: No chlorine bleaching.
5:Different washing machine models may cause slight differences in the fluffiness effect. Please adjust the washing method according to your desired fluffiness.
| COLOR FASTNESS(Average) | LIGHT COLOUR | SMEDIUM COLOUR | DARK COLOURS | Standard | |||
|---|---|---|---|---|---|---|---|
| Change | Stain | Change | Stain | Change | Stain | ||
| Dry cleaning | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 105 D01/GB/T 5711 |
| Acid perspiration | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 104 E04/GB/T 3922 |
| Alkaline perspiration | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 104 E04/GB/T 3922 |
| Washing | 3 | 4 | 3-4 | 3 | 3 | ISO 105 C06/GB/T 12490 | |
| Dry rubbing | 4 | 3-4 | 3 | ISO 105 X12/GB/T 3920 | |||
| Wet rubbing | 3-4 | 3 | 2-3 | ISO 105 X12/GB/T 3920 | |||
| Light (except white color) | 4 | 3-4 | 4 | ISO 105 B02/GB/T 8427 | |||
For above points marked by *,to refer to OEKO-TEX STANDARD 100 requirements
Above data are average values coming from tests carried out in our laboratories
