- Product details
- Washing instruction
1/8NM 100 COTTON
CS3131
应用
1. 7 针横机，1 根进线
2. 克重：265克/平方米
3. 抗起球标准：7200转(相同花型.针型.张力)为4级
4. 染色工艺：绞纱染色
5. 起订量：样纱10kg/色。
6. 参考分色卡：CRAFT'SOLID
APPLICATION
1. Flat Knitting machines 7 gauge 1 ply
2. Weight per square meter:gr265(on collection fabric on jersey stitch)
3. Pilling grade:4:has been tested on the collection swatch(same stitch/gauge/tension)according to Pilling box(ISO 12945-1/GB/T4802.3) at 7200 turns
4. DYEING PROCESS:Yarn dye
5. MINIMUN:The minimum for yarn dye is 10kgs(sample).
6. For further colors please refer to CRAFT'SOLID color card
织造：
1: 纱线已打蜡，尽量不回倒，若必须回倒，联系技术部。
2：成衣为避免色差，织造请连续编织，即前片-后片-衣袖保持同一台机器同一只筒子生产。
3：每个纱筒有5-6个手工打结处，织造请开启小接头探测器并归边；换筒时，首尾各拉2米，打结后归边，防接头两侧异常。
4：亚麻混纺纱织造：控制织机速度，车间湿度保持约 65%。亚麻刚性大，慎用绞花、四平等复杂组织，易破洞，投产前需试样。
5：织造时，损耗率15%，涵盖粗细不匀、色差、色花等导致的损耗。
6：收货后先试织，若有质量问题，15天内反馈。质量问题仅承担同等数量纱线，不负责面料织造和交货延期费用。
7：受该纱线工艺特性限制，每个筒子最内层纱线不可使用。
KNITTING：
1:The yarn is waxed. Do not re-spool unless necessary. If re-spooling is required, please contact our technical department in advance.
2:To avoid color variation in finished garments, continuous knitting is required: the front panel, back panel and sleeves must be produced on the same machine with the same yarn cone.
3:Each cone has 4-5 hand-tied knots. Enable the small joint detector and align selvedges during knitting. When changing cones, pull 2m from both ends, tie a knot, then align selvedges to avoid joint defects.
4:For linen-blend yarn knitting: control machine speed and keep workshop humidity at ~65%. Linen has high rigidity. Complex structures including cable stitch and double jersey are prone to holes; trial knitting is required before production.
5:During knitting, the standard wastage rate is 15%, covering losses caused by uneven yarn count, color difference, uneven dyeing, etc.
6:After receiving the goods, please conduct a trial knit first. Report any quality issues within 15 days. For confirmed quality problems, our liability is limited to providing replacement yarn of the same quantity. We will not cover costs related to fabric knitting or delivery delays.
7:Due to the special characteristics of this yarn, the innermost layer of yarn on each cone cannot be used.
工业洗涤指示：
1:不加助剂，冷水滚洗 6 分钟
2:熨烫温度小于110℃.
3:滚动烘干。
4：不可氯漂。
5：本洗水方式仅作参考，样衣试洗确认后，再启动大货洗水作业。
WASHING INSTRUCTION：
1: Wash with cold water without any detergents for 6 minutes.
2:Iron at a maximum sole-plate temperature of 110℃.
3:Tumble dry.
4：Do not use chlorine bleach.
5：This washing method is for reference only. Bulk washing may proceed only after the sample test wash is confirmed.
| COLOR FASTNESS(Average) | LIGHT COLOUR | SMEDIUM COLOUR | DARK COLOURS | Standard | |||
|---|---|---|---|---|---|---|---|
| Change | Stain | Change | Stain | Change | Stain | ||
| Dry cleaning | 3 | 3-4 | 3-4 | 3-4 | 4 | 3 | ISO 105 D01/GB/T 5711 |
| Acid perspiration | 3 | 3-4 | 3-4 | 3-4 | 4 | 3 | ISO 104 E04/GB/T 3922 |
| Alkaline perspiration | 3 | 3-4 | 3-4 | 3-4 | 4 | 3 | ISO 104 E04/GB/T 3922 |
| Washing | 3 | 3-4 | 3-4 | 3-4 | 3 | ISO 105 C06/GB/T 12490 | |
| Dry rubbing | 4 | 3-4 | 3-4 | ISO 105 X12/GB/T 3920 | |||
| Wet rubbing | 4 | 3 | 2-3 | ISO 105 X12/GB/T 3920 | |||
| Light (except white color) | 3 | 3 | 4 | ISO 105 B02/GB/T 8427 | |||
For above points marked by *,to refer to OEKO-TEX STANDARD 100 requirements
Above data are average values coming from tests carried out in our laboratories
