- Product details
- Washing instruction
2/4.2NM 80 CASHMERE 20 NYLON
CM0008
CM07NM
应用
3跟进线 566针横机
染色方法
3
特别说明
1:纱线已打蜡，非必要勿回倒，如需回倒请联系技术部
2:每个纱筒有4-5个手工打结处,织造请开启小接头探测器并归边;换筒时,首尾各拉2米,打结后归边,防接头两侧异常。
3:张力保持一致，深浅色因染色时间不同支数有差异，需按色调整工艺。
4:为避免色差，请连续编织，换筒子时请头尾各拉掉1M;如织复杂花型,可能会有破洞，请提前试样。
APPLICATION
Flat knitting machines 566 gauge 3 ply
Weight per square meter: 散毛染色 (on collection fabric on jersey stitch)
PILLING
Pilling grade: 色卡色30公斤/色,客制色100公斤/色 :has been tested on the collection swatch (same stitch/gauge/tension)
according to Pilling box(ISO 12945-1/GB/T 4802.3) at 7200 turns
DYEING PROCESS
BEST DYE-LOT
MINIMUM
CARE INSTRUCTIONS
1.The yarn has been waxed. Try to avoid rewinding it. If rewinding is necessary, please contact the Technical Department.
2.Each yarn cone has 4-5 hand - knotted areas. When knitting, please turn on the small joint detector and trim the edges. When changing the cones, pull out 2 meters from both the start and the end, tie a knot and then trim the edges to prevent any abnormalities on both sides of the joint.
3.maintain consistent tension.Adjust processes for dark/light colors due to count variations caused by different dyeing times.
4.To prevent color discrepancies,ensure continuous knitting.Discard 1M from both ends;Test swatches beforehand,as complex patterns may cause fabric breakage.
5.Protein fibers are acid-resistant but alkali-sensitive.Avoid alkaline detergents during washing.and post-finishing stains cannot be remedied by re-spinning.
FASTNESS
| COLOR FASTNESS(Average) | LIGHT COLOUR | SMEDIUM COLOUR | DARK COLOURS | Standard | |||
|---|---|---|---|---|---|---|---|
| Change | Stain | Change | Stain | Change | Stain | ||
| Dry cleaning | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 105 D01/GB/T 5711 |
| Acid perspiration | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 104 E04/GB/T 3922 |
| Alkaline perspiration | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 104 E04/GB/T 3922 |
| Washing | 3 | 4 | 3-4 | 3 | 3-4 | 3 | ISO 105 C06/GB/T 12490 |
| Dry rubbing | 4 | 3-4 | 3 | ISO 105 X12/GB/T 3920 | |||
| Wet rubbing | 3-4 | 3 | 2-3 | ISO 105 X12/GB/T 3920 | |||
| Light (except white color) | 4 | 3-4 | 4 | ISO 105 B02/GB/T 8427 | |||
For above points marked by *,to refer to OEKO-TEX STANDARD 100 requirements
Above data are average values coming from tests carried out in our laboratories
