- Product details
- Washing instruction
3/75NM 100%NAIA™ ACETATE
CS2474
应用
1. 14 针横机，1 根进线
2. 克重：190克/平方米
3. 抗起球标准：7200转(相同花型.针型.张力)为4级
4. 染色工艺：绞纱染色
5. 起订量：样纱10kg/色
6. 参考分色卡：ALFRED
APPLICATION
1. Flat Knitting machines 14 gauge 1 ply
2. Weight per square meter:gr190(on collection fabric on jersey stitch)
3. Pilling grade:4:has been tested on the collection swatch(same stitch/gauge/tension)according to Pilling box(ISO 12945-1/GB/T4802.3) at 7200 turns
4. DYEING PROCESS:Yarn dye
5. MINIMUN:The minimum for yarn dye is 10kgs(sample).
6. For further colors please refer to ALFRED color card
织造：
1.纱线已打蜡，非必要勿回倒，如需回倒请联系技术部。
2.换筒子首尾各拉除1-2米后接头归边处理，避免出现粗细毛及起横情况。
3.成衣为避免色差，织造请连续编织，即前片-后片-衣袖保持同一台机器同一只筒子生产。
4.织片缝盘及洗水环节需注意防止钩丝；为避免产生“鸡爪印”，建议衣物脱水后先小烫再进行烘干。
5.洗水需在中性条件下洗水，不可用强酸或强碱类洗剂，烘干温度不能超过80度。
6.中深色色牢度2－3级，如需要间色织，请在洗水时加入固色剂并先试洗样衣，再洗大货。
7.织造时，损耗率4%，涵盖粗细不匀、色差、色花等导致的损耗。
KNITTING：
1:The yarn has been waxed, please do not rewind. Please contact our technical department in advance if rewinding is considered nesessary.
2:During bobbin changing, pull out 1-2 meters from both ends first, then conduct edge-aligned joint treatment to avoid uneven thickness, fuzz, and horizontal stripes.
3:To avoid color deviation of garments, the knitting process shall be carried out continuously, the front panels, back panels and sleeves shall be produced on the same machine with the same cone of yarn.
4:During the linking and washing processes of knitted pieces, prevent snags; to avoid "chicken claw marks" (wrinkle defects), it is recommended to lightly press the garments after dehydration before drying.
5:Wash under neutral conditions; do not use strong acid or alkali detergents. The drying temperature shall not exceed 80℃.
6:Color fastness of medium to dark colors: Grade 2-3. If color-block weaving is required, add a fixative during washing, pre-test the sample garment first, then process the bulk production.
7:During the knitting process, the wastage is 4%, which includes the uneven thickness, color difference, uneven dyeing, etc.
工业洗涤指示：
1.30℃以下温水洗涤，加柔软剂，浸泡10-15分钟
2.熨烫温度小于110℃
3.滚筒烘干温度60℃~80℃
4.不可氯漂
5.不同洗衣机机型可能导致效果略有差异，请根据自身需求的状态调整洗涤方法
WASHING INSTRUCTION：
1:Wash in water under 30°C with softener, soak for 10-15 mins.
2:Iron at a maximum sole-plate temperature of 110℃.
3:Tumble dry on 60℃~80℃,
4:Cannot be chlorine bleached.
5:Slight variations in results may occur with different washing machine models. Please adjust the washing method according to your specific needs and fabric conditions.
| COLOR FASTNESS(Average) | LIGHT COLOUR | SMEDIUM COLOUR | DARK COLOURS | Standard | |||
|---|---|---|---|---|---|---|---|
| Change | Stain | Change | Stain | Change | Stain | ||
| Dry cleaning | 4 | 4 | 4 | 3-4 | 3-4 | 2-3 | ISO 105 D01/GB/T 5711 |
| Acid perspiration | 4 | 4 | 4 | 3-4 | 3-4 | 2-3 | ISO 104 E04/GB/T 3922 |
| Alkaline perspiration | 4 | 4 | 4 | 3-4 | 3-4 | 2-3 | ISO 104 E04/GB/T 3922 |
| Washing | 4 | 4 | 4 | 3-4 | 2-3 | ISO 105 C06/GB/T 12490 | |
| Dry rubbing | 4 | 3-4 | 3 | ISO 105 X12/GB/T 3920 | |||
| Wet rubbing | 4 | 3 | 2-3 | ISO 105 X12/GB/T 3920 | |||
| Light (except white color) | 4 | 3-4 | 4 | ISO 105 B02/GB/T 8427 | |||
For above points marked by *,to refer to OEKO-TEX STANDARD 100 requirements
Above data are average values coming from tests carried out in our laboratories
